Go Back   986 Forum - The Community for Porsche Boxster & Cayman Owners > Porsche Boxster & Cayman Forums > Boxster General Discussions

Post Reply
 
LinkBack Thread Tools Display Modes
Old 04-14-2017, 02:01 PM   #1
Registered User
 
Join Date: Jan 2013
Location: Houston
Posts: 370
Heavy oil consumption

I've had oil consumption ever since I bought the car 4 years ago at 45k miles. It was mostly a quart per 5k miles for 3.5 years until my AOS blew last fall. I replaced the AOS but my oil consumption vastly increased. I replaced the AOS again (assuming the new one was faulty) along with the PCV but the consumption remained high. No drips underneath. No unusual visible tailpipe smoke. Water fluid is clean. I did compression/leak down tests and the numbers were good.

I've now burned 7 quarts in the last oil change cycle of 5k miles with the car at 92k miles. Where else could my oil be going?

__________________
DD summer/winter: 2000 Boxster S
DD spring/fall: 914-6 w/ 3.0L SC Dual Webers

http://imgur.com/a/k0Wtl - My 914-6 Build/Project Story
patssle is offline   Reply With Quote
Old 04-14-2017, 03:16 PM   #2
"50 Years of 550 Spyder"
 
10/10ths's Avatar
 
Join Date: Jun 2015
Location: The Road
Posts: 918
just to clarify...

...seven quarts in 5,000 miles?
__________________
550 SE #310---"It's more fun to drive a slow car fast, than a fast car slow."
10/10ths is offline   Reply With Quote
Old 04-14-2017, 03:51 PM   #3
Registered User
 
Join Date: May 2014
Location: S.California
Posts: 2,027
There is a special way of testing for ovalized bores. Others may be able to explain that.
Does the rate of consumption vary depending if the sump level is max or min on the dipstick ?
Measure HC in the Exhaust?
Plug condition may give a clue?
Is drained oil filthy black (carbon)?

Last edited by Gelbster; 04-14-2017 at 03:55 PM.
Gelbster is offline   Reply With Quote
Old 04-14-2017, 08:33 PM   #4
Registered User
 
Join Date: Jan 2013
Location: Houston
Posts: 370
Yes 7 quarts. Consumption rate doesn't vary for the sump level. Oil is clean and more clean that it usually is after 5k miles due to the replacement oil.

I'll pull a plug tomorrow. I did read about the bores but if it was ovalized wouldn't that effect the compression/leakdown?

Thanks!
__________________
DD summer/winter: 2000 Boxster S
DD spring/fall: 914-6 w/ 3.0L SC Dual Webers

http://imgur.com/a/k0Wtl - My 914-6 Build/Project Story
patssle is offline   Reply With Quote
Old 04-14-2017, 08:37 PM   #5
Certified Boxster Addict
 
Join Date: Nov 2010
Location: Los Angeles
Posts: 7,669
7 quarts per 5000 miles is 714 miles per quart.

Porsche spec's excessive oil consumption at 600 miles per quart so while your experience is certainly on the higher side, Porsche would say that its within the range of expected oil consumption.

In regards to where the oil is going, there are only a couple of places it can go: external, coolant, or combustion chamber.

If there are no external leaks and the coolant looks clean, then its most likely going into the combustion chamber. Pull a couple of spark plugs to confirm. If this is the case, they will be coated in oil (whereas they should normally be a dry tan color).
__________________
1999 996 C2 - sold - bought back - sold for more
1997 Spec Boxster BSR #254
1979 911 SC
POC Licensed DE/TT Instructor
thstone is offline   Reply With Quote
Old 04-14-2017, 09:41 PM   #6
Registered User
 
Steve Tinker's Avatar
 
Join Date: Dec 2008
Location: Queensland, Australia
Posts: 1,522
Cylinders #5 & 6 seem to be the weaker bores according to Hartech in the UK - that's the 2 rearmost cylinders on the drivers side (LH drive cars). Valve stem seal/guide wear can also cause oil burning but I haven't heard of that in the M96 engines.
As Tom says, pull those 2 x plugs and compare with (say) #4 cylinder for comparison as they are all on the same side, though comparing all six plugs should give a better indication ....
__________________
2001 Boxster S (triple black). Sleeping easier with LN Engineering/Flat 6 IMS upgrade, low temp thermostat & underspeed pulley.
2001 MV Agusta F4.
Steve Tinker is offline   Reply With Quote
Old 04-15-2017, 04:56 AM   #7
Registered User
 
Join Date: Oct 2015
Location: Scituate MA
Posts: 869
This had me wondering, do you guys trust the electronic oil level sensor or always use the dip stick. I haven't used the stick in a while. Getting lazier as I get older.
DWBOX2000 is offline   Reply With Quote
Old 04-15-2017, 05:50 AM   #8
Registered User
 
Join Date: Apr 2016
Location: Tannersville PA
Posts: 471
I think Porsche calls 1.6 qt per 1000k an acceptable consumption. That seems a bit high.
achillies is offline   Reply With Quote
Old 04-15-2017, 06:32 AM   #9
2003 S, Arctic Silver, M6
 
paulofto's Avatar
 
Join Date: Oct 2014
Location: Winnipeg, MB, Canada
Posts: 1,348
Garage
Man that is a lot of oil. You'll have to start measuring your fuel economy in Miles Per Quart. Seriously though, if you are actually burning that much oil I can't imagine there not being a constant blue tinged exhaust and the exhaust tips showing evidence of oily residue.
paulofto is offline   Reply With Quote
Old 04-15-2017, 08:31 AM   #10
Registered User
 
Join Date: May 2014
Location: S.California
Posts: 2,027
5 &6 are 'at the end of the line' for coolant and oil circulation so are more prone to ovalisation but with this amount of consumption you have to think it would be more than just 2 cylinders?
As I speculated earlier- plugs will tell the story
Gelbster is offline   Reply With Quote
Old 05-28-2017, 08:32 PM   #11
Registered User
 
Join Date: Jan 2013
Location: Houston
Posts: 370
Finally got able to pull a plug. #6. This looks more like ash deposits from fuel. 13k miles on the spark plugs.



__________________
DD summer/winter: 2000 Boxster S
DD spring/fall: 914-6 w/ 3.0L SC Dual Webers

http://imgur.com/a/k0Wtl - My 914-6 Build/Project Story
patssle is offline   Reply With Quote
Old 05-29-2017, 08:18 AM   #12
Certified Boxster Addict
 
Join Date: Nov 2010
Location: Los Angeles
Posts: 7,669

__________________
1999 996 C2 - sold - bought back - sold for more
1997 Spec Boxster BSR #254
1979 911 SC
POC Licensed DE/TT Instructor
thstone is offline   Reply With Quote
Post Reply


Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On
Trackbacks are On
Pingbacks are On
Refbacks are On




All times are GMT -8. The time now is 07:37 AM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
Content Relevant URLs by vBSEO 3.6.0
Copyright 2024 Pelican Parts, LLC - Posts may be archived for display on the Pelican Parts Website -    DMCA Registered Agent Contact Page