The Sweet Smell of AntiFreeze

[Strawfordt]

Thoughts and or Opinions Appreciated.

When I go out for a drive I can't help but think that my vehicle is emitting an anti freeze like smell after I have warmed it up.

My A/F levels seem fine and the smell is noticeable when the top is down and the A/C / heater is turned off.

I've noticed that the smell is also present when I lift the deck lid.

Anyone know where I should be looking? Or for that matter even if I should be looking?

Thanks

Originally Posted by Strawfordt

Thoughts and or Opinions Appreciated.

When I go out for a drive I can't help but think that my vehicle is emitting an anti freeze like smell after I have warmed it up.

My A/F levels seem fine and the smell is noticeable when the top is down and the A/C / heater is turned off.

I've noticed that the smell is also present when I lift the deck lid.

Anyone know where I should be looking? Or for that matter even if I should be looking?

Thanks

Could be a leaking over flow reservoir. Lift your carpet and look underneath. This has been covered pretty extensively here. Do a few searches.

[bigislandboxster]

I get this same phenomenon with my car as well. Especially on warmer days or when I've driven the car for longer distances. I had the reservoir replaced a while back and the hoses, level is fine, no leaks whatsoever. Check under the carpet and board underneath by the reservoir as bmussatti says, but I think this isn't too uncommon.....

[Strawfordt]

BigIslandBoxster,

Do you still get the smell or did your parts investment solve the issue?

[bigislandboxster]

Do you still get the smell or did your parts investment solve the issue?

I had an actual leak earlier this year that was alleviated by replacing the hose and the clamp. The system was belched and repressurized as well. Even after that, I still will notice a little antifreeze smell from time to time, nothing REAL strong, but I can smell it a bit....No leaking tho, maintains proper engine temperature also. I also hardly ever use the AC either.... I don't know if that has anything to do with it tho. Do you have the updated cap for the reservoir bottle? Any condensation above the cap where the rear trunk lid sits over it?

All my fans are working properly as well, radiators and exhaust.....

[MNBoxster]

Hi,

The coolant reservoir doesn't really leak, the vinyl they're made of actually cracks due to heat cycling. The material used to make them has improved and the issue has largely gone away.

Another cooling system issue on the Boxster was Porsche's initial decision to use spring clamps on the hose connections rather than the more typical Worm Clamps (screw type). These spring clamps are problematic and Porsche has several TSBs recommending a switch to worm clamps anytime a portion of the cooling system is serviced or dismantled.

I suspect that if your coolant level is remaining static, you're probably smelling minute traces of glycol (coolant) which is seeping past some of these spring clamps. It doesn't take a whole lot of coolant to create a fairly prominent odor.

If you get the car on a lift, inspect all the clamps for signs of staining or mineral deposits where the hose joins the outlet. Replace that clamp, or bite the bullet and replace them all with SS Worm Clamps, more work than $$. Hope this helps...

Happy Motoring!... Jim'99

[Strawfordt]

Thanks to all,

How do I tell if my Cap is the updated one?

I checked at the dealer and they stated that the current part number for the cap is 996 106 44701. but they could not tell me how to tell if I have the "updated" one.

Thanks

Originally Posted by bigislandboxster

Do you still get the smell or did your parts investment solve the issue?

I had an actual leak earlier this year that was alleviated by replacing the hose and the clamp. The system was belched and repressurized as well. Even after that, I still will notice a little antifreeze smell from time to time, nothing REAL strong, but I can smell it a bit....No leaking tho, maintains proper engine temperature also. I also hardly ever use the AC either.... I don't know if that has anything to do with it tho. Do you have the updated cap for the reservoir bottle? Any condensation above the cap where the rear trunk lid sits over it?

All my fans are working properly as well, radiators and exhaust.....