Very Strange Steering Noise!

[steved0x]

Check behind the spare tire in the front trunk for the tool roll, they may include the correct allen key.

[luci5r]

Originally Posted by steved0x

Check behind the spare tire in the front trunk for the tool roll, they may include the correct allen key.

There was some stuff there, but no go on the allen key. Will have to pick it up today.

Originally Posted by Steve Tinker

Ahh, I didn't realise the 987 may have a different lock down system.
You will need to buy a cheap set of Allan keys from your local auto store - they are very cheap but without them you will not get them to unscrew.
Welcome to the slippery slope of car maintenance - if you spend too much time on 986 Forum, by next year you will be completing the major services on your car.....

Lol, that would be welcome. I do enjoy doing all this work on the car myself. Had a long running thread about a dead battery & trunk locked sometime back that I managed to resolve myself with all the help I received here.

Thanks guys. Will let you know about the screws.

[rdass623]

Originally Posted by steved0x

Check behind the spare tire in the front trunk for the tool roll, they may include the correct allen key.

finding the spare in a 987 is a bit of a problem... the spare is a bottle of tire sealant and a mini compressor...

[luci5r]

FAR more luck this morning guys!

So as it turns out, I did have the right allen key in my tool box. I have a set of about 18 allen keys & screw tips for one of my power screw drivers and one of them fit like a glove. It's the 5/32 key. As planned - I had sprayed some WD40 on the 5 screws and let it sit for about 20 minutes. Snapped the allen key on my power screw driver and the screws unscrewed with very little effort.

I have to say, WD40 has saved my life on more occasions then I care to remember.

Propping out the power steering fluid knob, there was absolutely no sign of fluid on the stick. Unfortunately the placement of the fluid container is such, with the seat back rear bar that you can't peep into it. For the life of me, from no angle, could I get a look into the container. Finally used a long, thing, plastic wire-tie. There's NO Fluid in the container. It's bone dry!! Very disturbing.

So at this point I have to pick up the Pentosin CHF 11 S synthetic hydraulic fluid from one of my local auto stores. I'm assuming this would be the right kind:

Pentosin CHF 11 S

This store is barely 5 minutes from my house. Online these 1 liter bottles are about $20, but can't find them any cheaper then $25 in most stores around here. Pep boys a bit down the road has the same for the same price. I'll probably just stop at O'Reilly.

Once I have the fluid replenished, I'll try driving around a little to see if the noise goes away. If it still doesn't, I'll have no choice but to bring it in to a shop.

Originally Posted by rdass623

finding the spare in a 987 is a bit of a problem... the spare is a bottle of tire sealant and a mini compressor...

LOL! I was going to mention. That's exactly what I have. The bottle of sealant & compressor. No spare.

Thanks guys.

[paulofto]

Originally Posted by luci5r

FAR more luck this morning guys!

So as it turns out, I did have the right allen key in my tool box. I have a set of about 18 allen keys & screw tips for one of my power screw drivers and one of them fit like a glove. It's the 5/32 key. As planned - I had sprayed some WD40 on the 5 screws and let it sit for about 20 minutes. Snapped the allen key on my power screw driver and the screws unscrewed with very little effort.

I have to say, WD40 has saved my life on more occasions then I care to remember.

Propping out the power steering fluid knob, there was absolutely no sign of fluid on the stick. Unfortunately the placement of the fluid container is such, with the seat back rear bar that you can't peep into it. For the life of me, from no angle, could I get a look into the container. Finally used a long, thing, plastic wire-tie. There's NO Fluid in the container. It's bone dry!! Very disturbing.

So at this point I have to pick up the Pentosin CHF 11 S synthetic hydraulic fluid from one of my local auto stores. I'm assuming this would be the right kind:

Pentosin CHF 11 S

This store is barely 5 minutes from my house. Online these 1 liter bottles are about $20, but can't find them any cheaper then $25 in most stores around here. Pep boys a bit down the road has the same for the same price. I'll probably just stop at O'Reilly.

Once I have the fluid replenished, I'll try driving around a little to see if the noise goes away. If it still doesn't, I'll have no choice but to bring it in to a shop.



LOL! I was going to mention. That's exactly what I have. The bottle of sealant & compressor. No spare.

Thanks guys.

Hmmmmm if the fluid is down substantially it could mean a few things that need checking further like a leaking fluid reservoir, steering pump or line. If the fluid is not down a whole lot and topping it off gets rid of the noise you might be golden but it doesn't explain why it was low. It's not like brake pads wearing and you get low on brake fluid.

[luci5r]

First off let me start by thanking absolutely everyone who posted here and helped me out.

So last evening I poured in the Pentosin CHF 11 S into the power steering fluid reservoir; took about half a liter or so of the bottle to bring it to the "Cold" marking on the measuring stick. After wrapping up the engine compartment, gave it about 20 minutes to sit and fired up the car. Absolutely no noise! I had noise up to the point where I went to the O'Reilly Auto Parts store to pick up the fluid. So it was a noticeable difference. However, as I stated in my original problem - the noise used to eventually go away. So I wasn't convinced problem is necessarily over.

Real test was starting the car first time in the morning. That is exactly what I did this morning. Absolutely NO NOISE! Drove the car a little, just cannot replicate the noise anymore. Unquestionably, as it appears for now, unless the problem reappears - the bone dry power steering fluid was the problem. Refilling it seems to have resolved it.

This saved me a trip to the shop and some chunk of money, since the car is no longer under warranty and everything would be out of pocket.

This is the second time now folks here have helped me diagnose and resolve an issue which otherwise would warrant a trip to the shop.

THANKS everyone for your input, advise and help.

Originally Posted by paulofto

Hmmmmm if the fluid is down substantially it could mean a few things that need checking further like a leaking fluid reservoir, steering pump or line. If the fluid is not down a whole lot and topping it off gets rid of the noise you might be golden but it doesn't explain why it was low. It's not like brake pads wearing and you get low on brake fluid.

That is a good question. I don't have the answer to that, and it is concerning. The car is about 11 years old and I'm the second owner. I've owned it for about 3 years now. I don't believe the fluid has ever been checked so I'm not sure when exactly the fluid emptied, or if it was ever checked / replenished in the 11 year life span of the vehicle. I'm really not sure.

At some point I plan on checking the fluid level, and also keep an ear out for the noise to reappear.

Thanks guys!

[kk2002s]

Keep an eye out front of the car and back of the car for fluid leakage.
The steering rack could be leaking or the power steering/reservoir/hoses could be leaking
Don't wait for the noise as then thing have gone to far and the $$$ to fix go way up
When ever I do anything fluid related I put news paper down under the car parked in my garage as an drip indicator until I'm sure things are dry

I have to ask. 3 years of ownership, have you ever gone into the engine compartment before or have you always had a mechanic service things?

There's not much in the engine compartment that needs servicing except steering fluid and Air filter but it's good to look around to see if something out of place

Pentosin CHF 11 S is $$$ I was a bit low so I tracked down a can @$25. Took so little to bring it to level now I have 99% of a can. just sitting there. Well it is good for Floor jacks

[luci5r]

Originally Posted by kk2002s

Keep an eye out front of the car and back of the car for fluid leakage.
The steering rack could be leaking or the power steering/reservoir/hoses could be leaking
Don't wait for the noise as then thing have gone to far and the $$$ to fix go way up
When ever I do anything fluid related I put news paper down under the car parked in my garage as an drip indicator until I'm sure things are dry

I have to ask. 3 years of ownership, have you ever gone into the engine compartment before or have you always had a mechanic service things?

There's not much in the engine compartment that needs servicing except steering fluid and Air filter but it's good to look around to see if something out of place

Pentosin CHF 11 S is $$$ I was a bit low so I tracked down a can @$25. Took so little to bring it to level now I have 99% of a can. just sitting there. Well it is good for Floor jacks

I did exactly that when I was pouring in the oil! Absolutely no leaks since last evening - nothing under the car, entire length. I was also quite concerned where did the fluid go so this I had in mind to check for any leakage. None so far, which is a good sign.

The car stands in my driveway, which is quite clean and lighter in color, so I will be keeping an eye on the pavement. Making sure there are no leaks. I know there haven't been any during the last year or so since this is where the car parks.

I had never gone into the engine compartment before. Yesterday was my first time. Quite frankly, the car has only gone into the shop maybe 2 times over the last 3 years I've owned it. It's actually 2 & half years to be accurate. An oil change and a break pads/rotor replacement - that's it. So quite honestly, I don't believe anyone, even a mechanic, has gone into the engine compartment since I've owned this car. Which is why i had to use WD40 to get the 5 screws loosened.

I had a battery issue where I had to replace the battery, run current to the jumpers to open the hood -- but none of that required the engine compartment and I was able to handle it by myself.

Now that you mention it - maybe I should check the air filter!!

Got the CHF 11S for the same cost - $25. But for me it took a little more then half the can, I believe a little over half liter. So I have less then half a can sitting now. Worked out well.

UPDATE #2: Took a longer drive. No noise, nothing whatsoever. Very smooth. In fact, I almost feel like the steering is handling smoother then it ever has in the last 2.5 years I've owned this car. Still no signs of any leakage anywhere.