electical burning smell

[Rfromet]

I've noticed that as well on my 2002...Always seems on the hottest days, coming from the driver side air intake...

[fullthrottle52]

Rfromet,

It's pretty scarry. It last about 5 to 10 seconds and smells like the rubber is burning off a wire. It has to be electical. It does seem to be coming from the air vert because it is kinda blown in your face. That is why I thougt it might be a radiator fan. I did have the CD playing. Wonder if it could be CD or radio?

Who know. I guess nobody else has had this issue based on the feedback.

It is somewhat helpful to know someone else has had this issue.

[stateofidleness]

Well I don't know if it helps, but on the way home just now (96 degrees out), I noticed my mileage "lcd screen" flickering. Not all of them, just the one that displays the mileage (bottom left).

It's never done this before, although I do have one of the gauge bulbs lose so the light behind the tach sometimes flickers. I attributed it to the heat inside the car. I tapped all over the gauge cluster and housing, but nothing helped.

Parked car (at subway) and when I came out to leave again, it was fine for about 10 seconds and then it started flickering again. It would update the numbers however. I thought I smelled something electrical, but it was so hot that I think I was "jumping to conclusions".

It is a bit unnerving, but I hope it's just a lose bulb connection.

On topic now, do you get the smell when all electronics are turned off? Checked the fuse panel?

[Beelzy]

If it didn't catch fire by now, it's entirely normal.

[fullthrottle52]

stateofidleness,

That is what I thought the first time it happened to me. It was a hot day and I wasn't sure I smelled burning. This time it was very evident. It was not nearly as hot last night. Maybe around 85 degrees.

I'm going to not worry to much about it. If it happens again then I'll try to narrow things down some.

Beelzy,
I thought about checking the fuse panel. I will try to do that tonight.

Thanks for the input.

[coolbreeze551]

I got the same smell after running the car a couple blocks after installing an EVO intake. I followed my nose to the drivers side air intake. I thought it was maybe just some rubber/plastic from the install that was maybe too close to something hot.... At least I hope

[mikesz]

been there done that. I bought my 99 in Feb '13. I am driving around and yes got the electric smell and my HVAC fan stop working so I take a look at the fuses and the one for the fan is melted, yeah the plastic piece on the fuse is melted. I have never seen that before so I replace the fuse. About a month later I am driving and all of a sudden the car just dies with no warning. Get towed to the dealer and they tell me the fuse for the fuel pump is melted and that there is damage to the fuse block. So they replace the fuse holder for that row in the fuse block. they check to make sure the fuel pump is working properly and it is. I get the car back and its running great. Go for a ride with the wife about a month later, I live in RI and its a very hot July day. On the way home my water temp light is flashing fortunately I am able to limp home. I check fuses for radiator fans right side is melted and left side is blown. Using a jumper wire and removing the relay's for the radiator fans I determine the right fan is not working at all and the left works only on high speed. When I replace the right fan I realize it was binding. I figure the left ballast resistor is gone but choose to replace the left fan too.

Might give you some ideas on where to start. Good Luck!